A Pressure Situation
The propane in your gas system is stored under pressure. While it's stored, there's no problem. But, in the
unlikely event your system develops a leak (which can be caused by physical damage or deterioration), it can
become dangerous.Propane burns at an even rate when properly mixed with air, as in your stove or furnace. But, if a leak occurs,
a flame or spark could ignite it. If that happens, it could cause a fire or even an explosion. Although such
accidents are rare, we want you to be aware of this possibility.
Know Your Propane System
Your propane system has four basic parts:
- A tank or cylinder, equipped with a main shutoff valve;One or more regulators designed to reduce pressure between the container and your appliance(s);Gas piping, to carry the propane to your appliance(s); and
- Gas appliance(s).
The tank or cylinder is where the propane is stored. It is equipped with a shutoff valve, which turns the gas
"on" or "off". The regulator controls the gas pressure, while the gas piping carries the gas to your
appliance(s).It is important for you to know the location of the main shutoff valve on the tank or cylinder. Remember its
location and become familiar with how to shut it off in an emergency situation.
How Do You Tell if There Is a Leak?
- By smell. A disagreeable odor is added to the propane so that you will be able to detect the smell
easily in case a leak develops or an unlit burner is left turned on.
- By electronic gas alarm. If used, the gas alarm supplements a person's ability to detect a gas leak
and sounds a warning when it detects the presence of unburned propane.
You should be aware that some persons have different thresholds of smell and cannot detect the odor of propane
as readily as others. Also, sometimes people with a normal sense of smell temporarily lose their ability to
detect odors because of illness, use of tobacco, alcohol or drugs. Also, cooking odors, tobacco smoke and
aerosol and odor removing sprays can cover up other odors. In certain instances, the odorant in the propane may
diminish or weaken, making it difficult for a person with a normal sense of smell to detect a gas leak. Be aware
that being heavier than air, leaking propane may tend to settle near the floor while dissipating into the air.
Steps to Take if You Smell Gas or the Alarm SoundsNever assume that the odor of gas is a sign that your tank is running low. If you smell gas in the house or
if the gas alarm signals the presence of gas, IMMEDIATELY follow these suggestions:
- Extinguish all smoking materials and any other open flames or sources of ignition. Get everyone outside and away from the building. Shut off the gas supply at the tank. Call your propane supplier from a neighbor's phone. If you cannot reach your propane supplier, call
the fire department.
- Stay outside and leave the gas off until the leak has been found and fixed.
- Turn light switches, appliances or thermostats on or off, and do not use the telephone. A spark from
one of these could ignite the gas.Light or try to re-light any appliances. Leave this job to your propane supplier.
- Re-enter the building, until the problem has been corrected.
Inspection of Your Appliance(s)
Routinely (at least annually) call a service technician to examine your gas appliance(s) for any conditions
that may render the appliance(s) inefficient or unsafe for use, similar to how you have your automobile
checked periodically. All appliances, including gas, should be regularly inspected and maintained, just as
electrical appliances, to eliminate possible hazards from short circuits and other malfunctions that could
create hazards.A routine inspection should consist of (but not be limited to) detecting any unsafe or potentially hazardous
situations, such as the following:
- Substandard and/or lack of venting systems on appliances requiring them.Sootiness and/or the accumulation of soot around interior and exterior appliance components such as around
pilot lights, appliance burners, range tops, oven components, etc. This indicates that the appliance is
not operating properly or efficiently.Leakage of water around or through water heater valves, fittings or jackets.
- CAUTION: This should alert
you to the fact that the water heating device has some internal damage.Missing or damaged control components such as dials, knobs, screws, etc.Controls that have been tampered with (evidenced by altered design function, missing or substituted
components, etc.).Controls that have been under water or subjected to flooding. Such controls may not function properly
and must be replaced.Unstable appliance bases and/or platforms. Warped, rotting or substandard bases and/or platforms may
collapse creating a potentially hazardous condition.Problems in gas line connectors such as kinks, corrosion, deterioration, etc. Any abnormality should be
immediately reported to your propane supplier since failure to correct these problems could create a
hazardous situation.Unsatisfactory operation of gas valves and safety controls.Gas leakage in the appliances or piping system.
- Improper appliance and gas system installation.
A Word About Vented Appliances
Some appliances are required to have vents in order to exhaust harmful combustion gases outside. Poisonous
carbon monoxide can be produced from improperly installed or operating appliances. Frequent headaches and
nausea may be indicators that this colorless, odorless gas is causing carbon monoxide poisoning. To minimize
the chance of this happening, follow these practices:
- Vented appliances must be installed by a qualified appliance installer.Do not operate vented appliances until they have been vented properly.After appliance installation and before each heating season, the vents and flues should be checked for
blockages and corrosion, either by a qualified installer or a qualified service technician.
- If you buy a used appliance, have it inspected and installed by a qualified propane appliance installer.
When properly installed and maintained, the venting system will also keep walls and other surfaces from
overheating and possibly catching fire. Not all gas appliances are suitable for operating on propane. If you
buy a used appliance, be sure it is listed for propane and have it installed by a qualified technician.
General Safety Precautions
Here are some general safety procedures to follow when using your propane appliance(s):
- Be alert for the odor of propane when around a gas appliance or container.If you smell gas, do not try to light the appliance. Call your propane supplier.Read and follow the operating and lighting instructions and warning labels provided by the appliance
manufacturer.The pilot has a safety device. If you have trouble keeping it lit, this device is warning you about
a problem. Call a service technician for assistance.
- Never force any appliance control. If you cannot operate the knobs, switches or buttons by hand, call
your supplier. Never tamper with the controls.
Additional Safety Tips
- Keep combustibles, such as curtains, paper, cleaning fluids, etc., away from any energy source,
including gas and electric appliances where they may cause a fire.Have a B/C rated fire extinguisher readily available. Be sure it is charged and that you and your
family know how to use it.Gas appliances, like humans, need oxygen (air) to function properly.If you smell gas near your tank or cylinder, call your propane supplier.Use only listed propane appliances. Look for the seal from a nationally recognized independent testing
- Use gas grills outdoors only. Use or store propane cylinders outdoors only.
If You Run Out Of Gas
Letting your propane container run empty creates additional hazards. If you run out of gas and lose pressure
in the system, a potentially hazardous condition can result. If you do run out of gas, follow these steps:
- Turn off all control valves on all gas appliances.Turn off the shutoff valve on the propane container(s). Call your propane supplier to arrange for delivery, and advise them you are out of gas.
- Don't turn the gas back on yourself. Let the propane supplier do it. When you schedule your fill, be
sure it is for a time when you will be at home, so the propane supplier can relight and check your
appliances and system to assure that they are operating properly and are leak free.
- Immediately after your tank is refilled, have a service technician check to see that all safety controls
are functioning properly and the piping system is leak free.
If You Move or Change Gas Appliances
ALWAYS CALL YOUR PROPANE SUPPLIER WHEN YOU NEED A GAS APPLIANCE CONNECTED OR DISCONNECTED. It is for your
safety that the gas system remain in a safe condition at all times. Should the gas system develop a leak
(or if a gas line or shut off valve remains unplugged), a fire, explosion or serious injury could result.
Properly operated and maintained, your propane system and appliance(s) can provide you many years of
clean-burning, safe efficient service. If you have any questions once you have read this information, or do
not understand any part of it, call your supplier.